HomeMy WebLinkAbout1930 PALOMAR POINT WAY; 105; CB071244; PermitCity of Carlsbad
1635 Faraday Av Carlsbad, CA 92008
07-12-2607 Commercial/Industrial Permit Permit No: CB071244
Building Inspection Request Line (760) 602-2725
Job Address: 1930 PALOMAR POINT WY CBAD St: 105
Permit Type: TI Sub Type: INDUST
Parcel No: 2121205000 . Lot #: 0 Status: ISSUED
Valuation: $9,742.00 Construction Type: NEW Applied: 05/04/2007
Occupancy Group: Reference #: Entered By:. LSM
Project Title: SONARTEC GOLF- INSTALL 10' Plan Approved: 07/12/2007
HIGH STORAGE RACKS Issued: 07/12/2007
Inspect Area:
Plan Check#:
Applicant:
COLBRESE MATERIAL HANDLING
SUITE .
12600 STOWE
POWAY CA 92109
858-486-6920
. ,.
.
.
Owner:.
LANIKAI.PARTNERS II
.. .
P p BOX 445
SANTA YNEZ CA 63460
Building Permit $99 69 Meter Size
Add 'I Building Permit Fee / $0:00 Add I Red Water Con Fee $0.00 Plan Check $64.80 Meter Fee $0.00
Add 'I Plan Check Fee $0.00 SDCWA Fee $0.00
Plan Check Discount . $0.00 CF.D Payoff Fee . . $0.00 Strong Motion Fee $2 05 P F F (3105540) $0.00
Park Fee $0.00 PFF (4305540) $0.00
LFM Fee $0.00 License Tax (3.104193) $0.00
Bridge Fee . $0.00 License Tax (4304193) . ., . $0.00 BTD #2 Fee $000 Traffic Impact Fee (3105541) $0.00
BTD #3 Fee $0.00 Traffic ImpactFee (4305541) $0.00
Renewal Fee $000 PLUMBING TOTAL $000
Add I Renewal Fee $0 00 ELECTRICAL TOTAL-$0 00
Other Building Fee WOO MECHANICAL TOTAL $0.00
Pot Water Con Fee .$0.00 Master Drainage Fee $0.00
Meter Size Sewer Fee $0.00
Add'l Pot. Water Con. Fee . $0.00 Redev Parking Fee .. . $0.00 Red. Water Con. Fee $0.00 Additional Fees $0.00
HMPFeé ??
TOTAL PERMIT FEES $166.54
Total Fees $166.54 Total Payments To Date $166 54 Balan6e Due $0.00
FINAL APPROVAL
Inspector: V' 1L4" Date: ori/ 9/c7 Clearance:
NOTICE: Please take NOTICE that approval of your project includes the "Imposition" of fees, dedications, reservations, or other exactions hereafter collectively
referred to as 'fees/exactions." You have 90 days from the date this permit was issued to protest imposition of thesd fees/exactions. If you protest them, you must
follow the protest procedures set forth in Government Code Section 66020(a), and file the protest and any other required information with the City Manager for
processing in accordance with Carlsbad Municipal Code Section 3.32.030. Failure to timely follow that procedure will bar any subsequent legal action to attack,
review, set aside, void, or annul their imposition.
You are hereby FURTHER NOTIFIED that your right to protest the specified fees/exactions DOES NOT APPLY to water and sewer connection fees and capacity
changes, nor planning, zoning, grading or other similar application processing or service fees in connection with this project. NOR DOES IT APPLY to any
fees/exactions of which you have previously been given a NOTICE similar to this, or as to which the statute 6f limitations has previously otherwise expired.
FOR OFFICE USE ONLY
PLAN CHECK NO.
PERMITAPPLICAT1ON ' ':
EST.VAL.t'74'2oo
Plan Ck.Depot (4. I'Q
CITY OF CARLSBAD BUILDING DEPARTMENT .. - Validated By
1635 Faraday Ave:, Carlsbad CA 92008 '. Date ' 57 '7'/b '
1. PROJECT INFORMATION -
'aIor.- Aj.
Address (I de Bidgl kite #). ( i .....- Business Name (at this address)
&Of1ifl'_-"Ok" 101 'j.
Legal 0esa4t1on ' Lot No. SubdivisionName/Number / -, Unit No. ' Phase No It Total # of units
Pro Use. CAE i bn Use
Description o ork SQ. FT. # of Stones # of Bed ooms #of Bathrooms
mame . .1 A00rSs , City ' Statelzlp 14 ITelephone # ' , ' Fax #
name ACCress -; - (j 'cay . State/Zip - 'Telehoñe # U a a24 0.1'..
Name (J Address City (J . V S1e/Zip Telephone#
(Sec. 7031.5 Business and Professions Code: Any City or County which requires a permit to construct alter, improve, demolish or repair any structure, prior to Its issuance,
also requires the applicant for such permit to file a signed statement that he is licensed pursuant to the provisions of the Contractor's License Law (Chapter 9, commending with
Section 7000 of Division 3 of the Business and Professions Code] or that he is exempt therefrom, and the basis for the alleged exemption. Any violation of Section 7031.5 by
anyapjcant fora pe"g sujeds the,appjiçant to I çivjl penalty çf not more than five hundred dollars ($5001). .. t)
Name
State License
- Address 0 ' /çi.4 City ''State/Zip - Telephone #
Ucense Class - ' - City Business License # I ')
Designer Name Address City State/Zip ' Telephone#
State License #______________
6WRKER'S"C'øMPENSATIaN
' Workers' Compensation Declaration: 1 hereby affirm under penalty of perjury one of the following declarations:
a I have and will maintain a certificate of consent to self-insure for workers' compensation as provided by Section 3700 of the Labor Code, for the performance of the work
for which this permit Is Issued.
I have and will maintain worker's compensation, as required by Section 3700'of the labor Code, for the perfo'rmance of the work for which this permit Is Issued. My
worker's compensatloninsMiance carrier and policy number are:
InsuranceCompany ')(.4 f ' PolicyNo.002' g4-0(7 4' ExpirationDate — I' 2°1
(THIS SECTION NEED NOT BE COMPLETED IF THE PERMIT IS FOR ONE HUNDRED DOLLARS ($1003 OR LESS)
a CERTIFICATE OF EXEMPTION: I certify that In the performance p of the work for which this miit is Issued, I shall not employ any person In any manner so as to
beâome subject to th orkers' Compensation L'aws of California
WARNING: Failure d shall subject an employer to criminal penalties and civil fines up to one hundred thousand
q /- SIGNATURE DATE
dollars($1 00,000), I ad iti Code, interest and aftomev'/o1 sjees
I hereby affirm that I am exempt from the Contractor's License Law for the following reason:
a r I, as owner of the property or my employees with wages as their sole compensation, will d the work and the structure' is not Intended or offered for sale (Sec. 7044,
Business and Professions Code: The Contractors License Law does not apply to an owner of property who builds or Improves thereon, and who does such work himself or
through his own employees, 'provided that such improvements are not intended or offered for sale. If, however, the building or improvement is sold within one year of
completion, the owner-builder will have the burden of proving that he did not build or Improve for the purpose of sale). - a i, as owner of the proerty, am exclusively contraing with licensed contractors to construct the project (S. 7044, Business and Professions Code: The Contractors
License Law does not apply to an owner of property who builds or improves thereon, and contracts for such projects with contractor(s) licensed pursuant to the Contractor's
License Law). ' . . '• - ' '
a lam exempt under Section Business and Professions Code for this reason:
I personally plan to provide the major labor and inaterials for construction of the proposed property improvement. 13-YES 0 NO -
I (have/have not) signed an application fora building permit for the proposed work. ,' I have contracted with the following person (firm) to, provide the proposed construction (include name / address! phone number / contractors license number):
I plan to provide portions of the work, but I have hired the following person to coordinate, supeivise and provide the major work (include name I address / phone number/
/ontractors license number): - -
I will provide some of the work, but I have contracted (hired) the following persons to provide the work indicated (Include name / address / phone number type of work):
'PROPERTY OWNER SIGNATURE - DATE
WHITE: File YELLOW: Applicant PINK: Finance -
p
PERMIT APPLICATION
CITY OF CARLSBAD BUILDING DEPARTMENT
1,635 Farádày Ave.', Carlsbad CA 92008
Page 2of2 .
[COMPLETE THIS SECTION FOR NON-RESIDENTIAL BUU..OING PERMITS ONLY
Is the applicant or future building occupant required to submit a business plan, acutely hazardous mater1pls•registration for or risk management and prevention program under
SectIons 25505,25533 or, 25534 of the Presley-Tanner Hazardous Substance Account Act? DYES NO
Is the applicant or future building occiint requited to obtain a permit from the air pollution control dislrit oralr quality management district? D YES .JiO
Is the facility to be cnstrued within 1,000 feet of the outer boundary'of a school site? 0 YES @LNO .
IF ANY OF THE ANSWERS ARE YES, A FINAL CERTIFICATE OF, OCCUPANCY MAY NOT BE ISSUED UNLESS THE APPLICANT HAS MET OR IS MEETING THE
REQUIREMENTS OF ThE OFFICE OF EMERGENCY SERVICES AND THE AIR POLLUTION CONTROL DISTRICT
I hereby affirm that there is a con?truction lending agency for the performance of the work for which this permit is issued (Sec. 3097(l) Civil Code). .
LENDERSNAME LENDER'S ADDRESS
=APPLICANT CERTIFICATION - I certity, that I have read the application and state that the above information ls.correctand that the information on the plans is accurate. I agree to comply with all City
ordinances and State laws relating to building construction [.hereby authorize representatives of the City of Carlsbad to enter upon the above mentioned property for Inspection
purpose I ALSO AGREE TO SAVE INDEMNIFY AND KEEP HARMLESS ThE CITY OF CARLSBAD AGAINST ALL LIABILITIES JUDGEMENTS COSTS AND I
EXPENSES WHICH MAY IN ANY WAY ACCRUE AGAINST SAID CITY IN CONSEQUENCE OF THE GRANTING OF THIS PERMIT
OSHA An OSHA permit is required for excavations of 5 &.d6 ep and demolition or construction of structures over 3 stones in height.
EXPIRATION: Eveiy permit Issued b e building Official under the provisions of this Code shall expire by limitation and become null and void If the building or work authorized
'by such permit is not commenced in 80 days or the datef such permit or if the building or work authorized by such permit is suspended abandoned at anytime after
the work Is commenced for a period 11 days ( ecti n 106.4.4 fif0m.Building Code). .•. -
APPLICANTS SIGNATURE DATE
WHITE: File YELLOW: Applicant PINK: Finance S
City of Carlsbad Bldg Inspection Request
For: 07/18/2007
-
Permit# CB071244 Inspector Assignment:
Title: SONARTEC GOLF- INSTALL 10
Description: HIGH STORAGE RACKS
Type: TI Sub Type: IN DUST
Phone: 8584866920
Job Address: 1930 PALOMAR POINT WY
Suite: 105 Lot 0
Location: Inspector: ;me, _
APPLICANT COLBRESE MATERIAL HANDLING
Owner: LANIKAI PARTNERS II
Remarks:
Total Time: • Requested By: ANITA
Entered By: CHRISTINE
CD Description Act • Comment • •
19 Final Structural
• -
Comments/Notices/Holds
Associated PCRs/CVs Original PC# •
CV070350 OPEN • H- NO PERMIT FOR STORAGE RACKS; •
•• Inspection History
Date Description Act !nsp Comments
EsGil Corporation
In Partnership with government for Bui(ding Safety
DATE: 5/22/07 O APPLICANT
URIS.
JURISDICTION: City of Carlsbad 0 FILE REVIEWER
PLAN CHECK NO.: 071244 SET:!!
PROJECT ADDRESS: 1930 Palomar Point Way #105
PROJECT NAME: Storage Racks for Sonartec Golf
LII The plans transmitted herewith have been corrected where necessary and substantially comply
with the jurisdiction's building codes.
The plans transmitted herewith will substáptially comply with the jurisdiction's building codes
when minor deficiencies identified below are resolved and checked by building department staff.
The plans transmitted herewith have significant dèficiecies identified on the enclosed check list
and should be corrected and resubmitted for a complete recheck.
The check list transmitted herewith is for your information. The plans are being held at Esgil
Corporation until corrected plans are submitted for recheck.
The applicant's copy of the check list is enclosed for the jurisdiction to forward to the applicant-
contact person.
LI The applicant's copy of the check list has been sent to:
Esgil Corporation staff did not advise the applicant that the plan check has been completed.
Esgil Corporation staff did advise the applicant that the plan check has been completed.
Person contacted: Telephone #:
Date contacted: (by: ) Fax
Mail Telephone Fax In Person
REMARKS: .1. .1. Fire Department approval is required 2 Citlto field verify that the path of travel
from the handicapped parking space to the rack area and the bathrooms serving the rack area
comply with all the current disabled access requirements.
By: David Yao Enclosures:
Esgil Corporation
LI GA []MB []EJ L] PC log
9320 Chesapeake Drive, Suite 208 • San Diego, California 92123 • (858)560-1468,* Fax(858)560-.1757r6
9
- - EsGul Corporation
In (Partners flip with çovernmentforBui&uing Safety
DATE: 5/16/07 O APPLICANT
JURISDICTION: City of Carlsbad 0 PLAN REVIEWER
0 FILE
PLAN CHECK NO.: 071244 SET:!
PROJECT ADDRESS: 1930 Palomar Point Way #105
PROJECT NAME: Storage Raëks for Sonartec Golf
LII The plans transmitted herewith have been corrected where necessary and substantially comply
with the jurisdiction's building codes.
LI The plans transmitted herewith will substantially comply with the jurisdiction's building codes
when minor deficiencies identified below are resolved and checked by-building department staff.
The plans transmitted herewith have significant deficiencies identified on the enclosed check list
and should be corrected and resubmitted for a complete recheck.
The check list transmitted herewith is for your information. The plans are being held at Esgil
Corporation until corrected plans are submitted for recheck.
LII The applicant's copy of the checklist is enclosed for the jurisdiction to forward to the applicant
contact person.
F71 I The applicant's copy of the check list has been. sent to:
Anita Thornton 12600 Stowe Dr. #3 Poway, CA
LII Esgil Corporation staff did not advise the applicant that the plan check has been completed.
Esgil Corporation staff .didadvise the applicant that the plan check has been completed.
Person contacted: Anita Thornton Telephone #: 858-486-6920
Date contacted 77/O1 (by) Fax #:
Mail Telephone yrFax k(/In Person
LI REMARKS:
By: David Yao Enôlosures:
Esgil Corporation
El GA [1 MB [1 EJ El PC 5/7
9320 Chesapeake Drive, Suite 208 • San Diego, California 92123 • (858) 560-1468 • Fax(858)560-1576
City of Carlsbad 071244
GENERAL PLAN CORRECTION LIST
IJURISDICtION City of Carlsbad PLAN CHECK NO.: 071244
PROJECT ADDRESS: '1930 Palomar Point Way #105
DATE PLAN RECEIVED BY DATE REVIEW COMPLETED:
ESGIL CORPORATION: 5/7 . 5/16/07
11 REVIEWED BY: David Yao
FOREWORD (PLEASE READ):
This plan review is limited to the technical requirements contained in the Uniform Building Code,
Uniform Plumbing Code, Uniform Mechanical Code, National Electrical Code, and state laws
regulating energy conservation, noise attenuation and disabled' access. This plan review is
based on regulations, enforced by the Building Department. You may have other corrections
based on laws and ordinances enforced by the Planning Department, Engineering Department
or Other departments. .
The following items listed need clarification, modification or change. All items must be satisfied
before the plans will be in conformance with the cited codes and regulations. ,Per Sec. 106.4.3,
1997 Uniform Building Code, the approval of the plans does not permit the violation of any
state, county or city law. . . .
Please make all corrections and submit two new complete sets of prints to:
ESGIL CORPORATION.
To facilitate rechecking, please identify, next to each item, the sheet of the plans upon
which each correction on this sheet has been made and return this sheet with, the
revised plans. .
Please indicate here if any changes have been made to the plans that are not a result of
corrections from this list. If there are other changes, please briefly describe them and where
they are located on the plans. Have changes been made not resulting from this list?
El Yes UNo
City of Carlsbad 071244.
S/ O7
1. Only the storage racks are included in this plan review
2 Provide a statement on the Title Sheet of the plans that this project shall comply with
Title 24. '
3. UBC Section 107.2 requires the Building Official to determine the total value of all
construction work proposed under this permit. Please provide a signed copy of the
designer's or contractor's construction cost estimate of all work proposed
4. Provide a note on the plans indicating if any hazardous materials will be stored and/or
used within the building which exceed the quantities listed in UBC Tables 3-D and 3-E.-
5. Obtain Fire Department approval for groups F, M and S occupancy storage per UBC
Sections 306.8, 309.8 and 311.8.
6. City to field verify that the path of travel from the handicapped parking space to the rack
area and the bathrooms serving the rack area comply with all the current disabled access
requirements.
Recheck the "pallet" racks as follows:
7. Recheck all connections on sheet 1 as follows:
The rivet bearing capacity is only dtF = 0.406(0.0747)65 = 2 kips.
Provide calculations for all beam, to bracket weld capacities, per Section 2330
(allowable weld stress is the member thickness times 26 ksi times 1.33, or the
weld stress, whichever is lower).
Check the bracket maximum weak axis moment.
8. Provide calculations for the column weak axis bending plus axial for transverse seismic
loading. The axial load is the maximum compression load at the basefrom vertical.plus
,seismic overturning. The column moment will probably be maximum for the lateral load
from the base plate to the first diagonal brace (not only to the first horizontal member).
9 . The jurisdiction has contracted with Esgil Corporation located at 9320 Chesapeake Drive,
Suite 208, San Diego, California 92123; telephone number of 858/560-1468, to perform
the plan review for your project. If you have any questions regarding these plan review
items, please contact David Yao at Esgil Corporation. Thank you.
City of Carlsbad 071244
VALUATION AND PLAN CHECK FEE'
JURISDICTION: City of Carlsbad PLAN CHECK NO.: 071244
PREPARED BY: David Yao 'DATE: 5116/07
BUILDING ADDRESS: 1930 Palomar Point Way #105
BUILDING OCCUPANCY: ' TYPE OF, CONSTRUCTION:
BUILDING
PORTION
AREA
(Sq. Ft.)
Valuation
Multiplier
Reg.
' Mod.'
VALUE ($)
racks ' 6500 1.11 7,215
Air Conditioning
Fire Sprinklers
TOTAL VALUE 7,215
Jurisdiction Code Icb ' IBY Ordinance
Bldg. Permit Fee by Ordinance
Plan Check Fee by Ordinance
Type of Review: El Complete Review fl Structural'Only
El Other
El Repetitive Fee
[1 Repeats o Hourly • ' ' Hour *
Esgil Plan Review Fee
Comments:
$84.29
I $54.791
$47.201
Sheet 1 of 1
macvalue.doc
PLANNING/ENGINEERING APPROVALS•
PERMIT NUMBER CB 7 DATE 7/Y7c y
ADDRESS
RESIDENTIAL TENANT IMPROVEMENT
RESIDENTIAL ADDITION MINOR PLAZA CAMINO REAL
(< $10,000.00)
S. CARLSBAD COMPANY STORES
VILLAGE FAIRE
COMPLETE OFFICE BUILDING
OTHER
PLANNER
-ENGINEER
DATE
DATE
- oocslMlsrcrmsiplannlng Engineering ApprOvai5
PLANNING DEPARTMENT
, BUILDING PLAN CHECK REVIEW CHECKLIST
Plan Check No. CB 07-1244Address:' 1930 Palomar Point Way #105
¶ Planner: Jo Marquez Phone: (760)602-4619
APN: 212-120-33-00
Type of Project & Use: TI Net Project Density: DU/AC
Zoning:P-M General Plan: PI - Facilities Management Zone: 5
CFD (in/out) # Date of participation: Remaining net dev acres: -.
ç7, Circle One 1
• (For non-residential development: Type of land used created
bythis permit:___________________________________________________
Legend: Z Item Complete Qltem Incomplete - Needs your action
LI LI Environmental Review Required: YES NO X TYPE
DATE OF COMPLETION:
Compliance with Conditions of approval? If not, state conditions which require action.
Conditions of Approval:
LI LI Discretionary Action Required: YES NO X TYPE
APPROVAL/RESO. NO. DATE
PROJECT NO.
OTHER RELATED CASES:
Compliance with conditions or approval? If not, state conditions which require action.
Conditions of Approval:________________________________________________________
LI LI Coastal Zone Assessment/Compliance
Project site located in Coastal Zone? YES_____ NO X
CA Coastal Commission Authority? YES NO
If California Coastal Commission Authority: Contact them at - 7575 Metropolitan Drive, Suite 103,
San Diego CA 92108-4402; (619) 767-2370
Determine status (Coastal Permit Required or Exempt):
LI LI Habitat Management Plan
Data Entry Completed? YES NO _X
If property has Habitat Type, identified in Table 11 of HMP, complete HMP Permit application and
assess fees in Permits Plus ,
(A/P/Ds, Activity Maintenance, enter CB#, toolbar, Screens, HMP Fees, Enter Acres of Habitat Type
, irrpaôfed/taken, UPDATE!)-' .
LI LI Inclusionary Housing Fee required: YES NO X
(Effective date of lnclusionary Housing Ordinance - May 21, 1993.)
Data Entry Completed? YES NO
(A/P/Ds, Activity Maintenance, enter CB#, toolbar, Screens, Housing Fees, Construct Housing Y/N,
Enter Fee, UPDATE!)
H:\ADMIN\COUNTER\BldgPlnchkRevChklst Rev 3/06
Site Plan:
LI LI Provide a fully dimensional site plan drawn to scale. Show: North arrow, property lines, easement
existing and proposed structures, streets, existing street improvements, right-of-way width,
dimensional setbacks and existing topographical lines (including all side and rear yard slopes).'-
Provide legal description of property and assessor's parcel number. -
Policy 44 - Neighborhood Architectural Design Guidelines
LI LI 1. Applicability: YES NO
LI LI 2. Project complies YES NO '
Zoning:
LI LI 1.' 'Setbacks:
Front: Required Shown
Interior Side: Required Shown
Street Side: Required ' Shown -
Rear: Required ' Shown
Top of slope: Required Shown
LI LI 2. Accessory structure setbacks:
Front: ' Required Shown
'Interior Side: Required Shown
-
Street Side: Required Shown
Rear: Required ' Shown
Structure separation: ' Required Shown
LI LI Lot Coverage: Required Shown
LI LI 'Height: ' ' Required Shown
LI LI Parking: Spaces Required ' Shown
(breakdown by uses for commercial and industrial projects required)
Residential Guest Spaces Required Shown
(zX]LI Additional Comments: Correction #1- Please show the required parking spaces for this site, see
attached for further information, thank you!
OK TO ISSUE AND ENTERED APPROVAL INTO COMPUTER OATl 7
H:'ADMIN\cOUNTER\BldgPlnchkRevChklst Rev 3/06
MEM Carlsbad Fire Department
Plan Review Requirements Category: TI, INDUST
Date of Report: 07-11-2007
Name: Coibrese Material Handling
Address:
BUILDING DEPT
copy
44t
CARLSBAD FIRE DEPARTMENT
Permit #: CB07 1244
Job Name: SONARTEC GOLF- INSTALL 10'
Job Address: 1930 PALOMAR POINT WY CBAD St: 105
. 11FWLFftThe item you have submitted for review is incomplete. At this time, this office cannot
adequately conduct a review to determine compliance with the applicable codes and/or standards. Please review
carefully all comments attached: Please resubmit the necessary plans and/or specifications, with changes "clouded",
to this office for review and approval-.
Conditions:
Cond:CON0002107
[MET] Comply with Articles 1 and 81 of the California Fire Code for high-piled combustible storage
Please complete attached 'Statement of Intended Use'.
Provide additional information on the existing or proposed smoke removal system, type, location,
and specifications of smoke removal system.
provide additional information on commodity(ies) to be stored in accordance with Article 81 of the
CA Fire Code. (combustibles, non-combustibles, plastics etc.)
Provide information on maximum pile volume for each storage array.
High piled combustible storage is storage of combustible materials of more than 500 square feet
where materials are stored over 12 feet in height from the floor to the top of the storage. For
certain high-hazard commodities, storage height over '6 feet will require a permit from the fire
department.
Entry: 05/18/2007 By: GR Action: CO Entry: 07/11/2007 By: gr Action: AP
Cond: BP023
[MET] Refer to Article 1 of the California Fire Code for permits required for this process.
Entry: 07/11/2007 By: gr Action: AP
Action Comments L - By'I Date -
CO GR 05/18/2007
AP GR 06/12/2007,
Carlsbad Fire Department
Plan Review Requirements Category: TI, INDUST
Date of Report: 05-18-2007
BUILDING DEPT.
COPY
Reviewed by:
Name: Coibrese Material Handling
Address:
Permit #: CB07 1244
Job Name: SONARTEC GOLF- INSTALL 10'
Job Address: 1930 PALOMAR POINT WY CBAD St: 105
INCOMPLETE The item you have submitted for review is incomplete. At this time, this office cannot
adequately conduct a review to determine compliance with the applicable codes and/or standards. Please review
carefully all comments attached. Please resubmit the necessary plans and/or specifications, with changes "clouded",
to this office for review and approval.
Conditions:
Cond: CON0002 107
[MET] Comply with Articles 1 and 81 of the California Fire Code for high-piled combustible storage.
Please complete attached 'Statement of Intended Use'.
Provide additional information on the existing or proposed smoke removal system, type, location,
and specifications of smoke removal system.
provide additional information on commodity(ies) to be stored in accordance with Article 81 of the
CA Fire Code. (combustibles, non-combustibles, plastics etc.)
Provide information on maximum pile volume for each storage array.
High piled combustible storage is storage of combustible materials of more than 500 square feet
where materials are stored over 12 feet in height from the floor to the top of the storage. For
certain high-hazard commodities, storage height over 6 feet will require a permit from the fire
department.
Entry: 05/18/2007 By: GR Action: tO
Cond: BP023
[NOT MET] Refer to Article 1 of the California Fire Code for permits required for this process.
MAY-1 -2U01 FRI 04:57 PM CMH INC. FAX No. 858 486 6925 P. 005
BY........ P....NJAN : RACK DESIGN & ENGINEERING CO.
. 412 WEST BROADWAY #204 SHEET NO.........................
GLENDALE, CA; 01,204 JOB NO... ..... SUBJECT TEtft81a)240-aaió J'x.(ei6)U0-3e13
5 a 4,tA re c 40Lp
-
7,91 PLA IV ,ø8h
04
1O*
ol
y 33 >
It ..
f r .r2. l.iA.,#.0 PI4 Z8 jk.
1-7
0'7 /R V IS3Q >1 ct8E-D-ete E0:6Z Le/1tIqc4
BY; RAdK DEIdN & EN(INEERIN( do.
DATE 412 WEST BROADWAY, ØrrE #204 SHEET NO..........................
dLENDALE,. dA. 91204 JOB NO...J?T SUBJECT TEL:(818)240-3810 FAX:(818)240-3813
STRUCTURAL CALCULATIONS OF STORAGE
RACKS FOR: . . S
SONARTEC GOLF . . .
1930 PALOMAR POINT WAY . . .
CARLSBADE, CA. 92008 .
PER CBC 2001 EDITION
STORAGE RACKS CAPACITY:
1 000 # / LEVEL AT 2 & 3 BEAM. LEVEL RACKS
500 # / LEVEL AT 4 BEAM, LEVEL RACKS
CALCS. 1 THRU 5
DRAWINGS: RD-1 2063
/7 OH4
in Lu No. cO53524
EXP.: 6/30/07
S 4). Ze)
SIDE VIEW
RACK DEIN & ENaINEERINQ Co. 2
DATE 7 412 WEST BROADWAY. SUITE #204
SHEET NO.........................
GLENDAlE, CIA. 91204 JOB NO..
SUBJECT 'rEL:(818)240-3810 FAX:(818)240-3813
96"
500 #1 LEVEL
'4F H
TYPE "C"
I
CI6"
T
U
96"
TYPE "A'1 TYPE "B'.
96"
1
1000 #1 LEVi
96' If
0
ur
TYPE "0" TYPE 'E" . TYPE "F" SIDE VIEW
1'
1000 / LEVEL
TYPE "0',
r
48
----i 1AC_ LONG EAM 'x
S=1.2
Fy =50 K5 1.
cq =4<1.2 12 3/4"
. = 5xWxL_ 3" <144_ 8"
384xI, xE 180 -.
...
SIDE VIEW
1000 #/ LEVEL+25% IMPACT C3x3.5 BEAM
LOAD 600 #1 BEAM
I=1.44 [[ I=139
S=73 - Sx=.92
rn
Fy 50K5L Fy=5oKst.
1.2 3/4j
95'• BEAM
M 6"x6K =7.2"K
s.7*K= .24<73
= 5xWxL....
384xlx xE so
1 "K
8 ".
0
.6 "'
6 K
BY .RAdK DEIdN .& . .EN(INEERIN( do..
DATE ......4T. 412 WEØT BROADWAY, ØUITE #204 SHEET NO.
6rEN1iii, .dA. 91204 JOB NO....?T SUBJECT
. TEL:(818)20-3810 FAX:(818)240-3813
SEISMIC DESIGN . .
2.5xCaxI x W CBC 2001 SEC. 2222
WORKING
1=1 STRESS
R=5.6 MOM. CONN: • S • S • .
R=4.4 BRACED
Ca=.44 . S
W=D.L.+L.L. . . . S • S • S •
LONGIT. SEISMIC. . . • . S • S
LOAD PER COLUMN S S . . •
2 BEAM LEVELS: . . . .
- r 2 K
F 2x1K_IK . S co . S
,2 COL. . . . S. .
_.07' 2"xi 6,'K
W=.lDLI 1L.L. 1.1 K
. S . • • • :
v 2.5x.44x1.1 =.'1.5 K . •. . .
LONGIT. 5.6x1.4 . . . . .
V =2.5x.44x1.1 = K
TRANS. 4.4x1.4 . . •55
-:;--5.K 0 . .
3 BEAM LEVELS
-
3x1K —15K
2 COL.
W=.lDl 15L.L
1.6K
V ._2.5x.44x1.6 =.22K LONGIT. 5.6x1.4
V = 2.5x.44x1.6 =.28 K
TRANS. 4.4x1.4
4 BEAM LEVELS
p= 4X.5K._1
2COL.
D1t 1L.CT 1•1K
V = 2.5x.44x1.1.... .15x
LONGIT. 5.6x1 .4
BY ......... ...OHAN1AN. RAciK DEIdN & ENdINEERINc4 do.
DATE . ..... 4-2--O7 412 WET BROADWAY, U1TE #204 SHEET NO ........... .4
12063 (LENDALE, CIA. 91204 JOB NO. ...?T SUBJECT TEL:(818)240-3810' FAX:(818)240-3813
COLUMN ANALYSIS
1 5/8W 'I
Fy"50 KSI JJ_40x1.7_.62 Fe=''1!2 =64
T- A=.43 x 1.1 (K ) 2
ry 1 42 Sx:.36 ry .63 Fn — !L)4OKsI
r y =. M0xSx.Fb=11 K
P'=FxA= 17K
Pa 192
COMBINED STRESS RATIO
-+J-= 11i -ii- = .90<1.33
1.6K
BASE PLATE
ANCH: TENSION = 0
ANCHOR SHEAR = .22 K BASE PLATE
(1)-1/2"0 HILTI KWIK BOLT-3 ANCHOR
ESR-1385 OR APPROVED EQUAL. DESIGNED FOR
1/2 STRESS. (No SPECIAL INSPECTION REQ'D)
ALLOW. TENSION=.9 K
ALLOW: SHEAR=1.5K
p 5/3 v 5/3 5/3 22 5/3
(-) +(-) =(--) +(—) = .04<1.33 a a 1.5
RACK COLUMNS' DESIGNED SUCH THAT IF THE FRONT COL.
IS DAMAGED THE REAR COL. HAS EXTRA CAPACITY TO SUPPORT
THE FULL LOAD OF THAT BAY, (SEC. 2222-5)
MOMENT AT BEAM CONNECTION
7/1 6"ø RIVET •, .
A.1 Fy79 KSI
Va .1x79x.4 3K 5K
Ma 3Kx4"x1.33=16 2 OR 3 PIN CONN.
CONN. '
2"K
I.
5 K
L
10 0
8 K
BOTH SIDES TYP
Fi
t=.O7'
BY .c.:...PftN!AN. RAdKDEliN &. ENINEERIN do.
'DAit 412 WET BROADWAY, UITE #204 SHE NO. .
S
(LEDALE, dA. .91204 JOB NO. SUBJECT TEL'.-(818)240-3810 FAX (818)240-3813
OVERTURNING TOP LEVEL LOADING
MOT= .28Kx2x88x.5x.1.15 28 "K M01=.O9Kx2x88" 16 "K
MR = 1.6Kx42 =67K MR=.65Kx42"=27
I.
"K5
NO UPLIFT
LOAD TO DIAGONAL
P = .28Kx2x.2 =.691(
42
F=50 KSI
A=.31 F0= 123KS1
r=.48 P =
Q.=.74 a
L= 56"
CHECK WELDS
1/8" WELD 1.5" LONG EACH ,SIDE (3" TOTAL)
3x.125x.707x70x.3 =
CHECK SLAB
1600 1.6x144=230D"
M(*f)2x1000x .fxl2=510"#
512x52 50
510
50 =10<1.6V=80
1600#
1 5" CONCRETE SLAB
2500 PSI. CONC. irii / 1•000 PSF. SOIL
'F'
•4,
4" , 3.5" . .
15" -